2020 Chevrolet Silverado 1500 Problems, Recalls & Reliability
1,031 owner complaints sit in the federal file for the 2020 Chevrolet Silverado 1500, alongside 12 recall campaigns and 3 defect investigations. It scores 32/100 on the trouble index — a middle-of-the-pack year for this model. Engine leads the reports, typically around 69,000 miles.
Typical
Where 2020 sits among all Silverado 1500 years
What owners report
“The engine started making a strange sound while driving. Was taken to dealership were it was found that the engine was going bad due to a lifter failure. The engine only has 64,000. Miles on it and was maintained by dealerships for routine service.”— owner report to NHTSA, 2020 Silverado 1500
“While driving my transmission has a shutter. The shutter started about yr and half ago and I have just maintained with shutter stop. I know there is a recall on manufactured parts for other Chevrolet trucks in the same yr”— owner report to NHTSA, 2020 Silverado 1500
“There was a brake system failure and the brakes stopped working while going 50 mph”— owner report to NHTSA, 2020 Silverado 1500
“Brake system failure light, steering assist reduced drive no faster than 62 mph service trailer brake, service esc. Brakes went to the floor and did not want to stop.”— owner report to NHTSA, 2020 Silverado 1500
“Engine start to make noise while driving Took my truck to a auto shop Mechanic said that it is a fabric defective engine”— owner report to NHTSA, 2020 Silverado 1500
“No power steering alert showed up to service power steering. Very dangerous driving and power steering goes out.”— owner report to NHTSA, 2020 Silverado 1500
Mileage when trouble shows up
Among the 276 reports that include an odometer reading, problems most often appear around 25,000 miles. Half of those reports fall between 4,000 and 78,000 miles — a useful range to weigh against the mileage of the exact car you're looking at.
Recalls (12)
General Motors, LLC is recalling certain 2020 Chevrolet Silverado 2500, 3500, GMC Sierra 2500, 3500, and 2020-2022 Chevrolet Silverado 1500 and GMC Sierra 1500 vehicles that may have been repaired incorrectly under recall 24V797. The transmission control…
Fix: Dealers will inspect the vehicles and update the transmission control software, free of charge. Owner notification letters were mailed March 6, 2026. Owners may contact GMC customer service at…
General Motors, LLC (GM) is recalling certain 2020-2022 Chevrolet Silverado 1500, 2500, 3500, GMC Sierra 1500, 2500, 3500, 2021 Cadillac Escalade, Escalade ESV, Chevrolet Tahoe, Suburban, GMC Yukon, and Yukon XL vehicles equipped with diesel engines. The…
Fix: Dealers will install new transmission control module software, free of charge. GM will provide a special coverage program to cover the repair of transmissions that are identified by the remedy…
General Motors (GM) is recalling certain 2019-2021 GMC Sierra 1500 and Silverado 1500 vehicles equipped with certain accessory road tires and a 17" spare tire. The 17" spare tire provided with the vehicle is not compatible for use with the accessory wheels,…
Fix: Dealers will provide a new 17" spare tire and wheel assembly that is compatible with the accessory wheels, free of charge. Dealers will also apply a new spare tire information label, and provide…
General Motors LLC (GM) is recalling certain 2020 Buick Enclave, Cadillac XT4, XT5, Escalade, Escalade ESV, Chevrolet Suburban, Tahoe, Traverse, GMC Yukon, Yukon XL, 2018-2021 Chevrolet Express, GMC Savana, 2019-2020 Chevrolet Blazer, Silverado 1500, GMC…
Fix: GM will notify owners, and dealers will inspect the tires, replacing them as necessary, free of charge. The recall began March 22, 2021. Owners may contact GMC customer service at 1-888-988-7267,…
General Motors, LLC (GM) is recalling certain 2019-2021 Chevrolet Silverado 1500 and GMC Sierra 1500, 2021 Chevrolet Suburban and Tahoe and GMC Yukon XL and 2020-2021 Chevrolet Silverado 2500 and 3500 and GMC Sierra 2500 and 3500 vehicles. The seat belt…
Fix: GM will notify owners, and dealers will inspect left-side and right-side front-row center seat-belt bracket attachments and reassemble it correctly as necessary, free of charge. The recall began…
General Motors LLC (GM) is recalling certain 2020 Buick Enclave, Cadillac XT5, GMC Acadia and Chevrolet Traverse vehicles and 2020-2021 Chevrolet Silverado 1500, GMC Sierra 1500 vehicles. The vehicles may have been manufactured with Continental tires that…
Fix: GM will notify owners, and dealers will inspect vehicles and replace tires that have DOT number and production mold number combinations identified by Continental, free of charge. The recall began…
General Motors LLC (GM) is recalling certain 2019-2020 Chevrolet Silverado 1500 and GMC Sierra 1500 and 2020 Chevrolet Silverado 2500 trucks. One of the driveshaft joints may not have been properly welded, causing the driveshaft to separate while the vehicle…
Fix: GM will notify owners, and dealers will replace the driveshaft, free of charge. The recall is expected to begin December 2020. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC…
General Motors, LLC. (GM) is recalling certain 2020 Buick Enclave, Cadillac XT5 and XT6, Chevrolet Blazer, Silverado 1500, 2500 and 3500 and Traverse and GMC Acadia and Sierra 1500, 2500 and 3500 vehicles. The diffuser component of the Roof-Rail Air Bag…
Fix: GM will notify owners, and dealers will replace the suspect RRAB modules, free of charge. The recall began September 3, 2020. Owners may contact Chevrolet customer service at 1-800-630-2438,…
General Motors LLC (GM) is recalling certain 2020 Chevrolet Silverado 1500 and GMC Sierra 1500 vehicles. The bolts used to attach the front and/or rear brake calipers may have not been heat treated and may break under load.
Fix: GM will notify owners, and dealers will replace the brake caliper bolts, free of charge. The recall began March 23, 2020. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC…
General Motors LLC (GM) is recalling certain 2019-2020 Chevrolet Silverado 1500 and GMC Sierra 1500 trucks. The battery positive (B+) cable rings may have been manufactured with excessive glue, potentially causing an intermittent electrical connection…
Fix: GM will notify owners, and dealers will inspect for the presence of glue or other contamination at the B+ cable attachment to the alternator and clean the connection and reattach the B+ cable…
General Motors LLC (GM) is recalling certain 2020 Cadillac Escalade, Escalade ESV, Chevrolet Camaro, Silverado 1500, Suburban, Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles. The fuel pump may be missing a pressure regulator, allowing for…
Fix: GM will notify owners, and dealers will replace the fuel pump, free of charge. The recall began December 18, 2019. Owners may contact Cadillac customer service at 1-800-333-4223, Chevrolet customer…
General Motors LLC (GM) is recalling certain 2019-2020 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2020 Silverado 2500, Silverado 3500, Sierra 2500, and Sierra 3500 vehicles equipped with carpet floor covering. When the front seat belt pretensioners…
Fix: GM will notify owners, and dealers will close off the opening in the pretensioner bracket, free of charge. The recall began December 13, 2019. Owners may contact Chevrolet customer service at…
Federal defect investigations
Still open as of the last data refresh. An investigation is not a recall; it may close with no action. All open investigations →
Component: ENGINE AND ENGINE COOLING:ENGINE:HARD PARTS INTERNAL/MECHANICAL
The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024…
Led to recall campaign 25V274.
Technical service bulletins
1,548 manufacturer communications — service bulletins, the biggest share on engine and electrical — are on file for the 2020 Chevrolet Silverado 1500. A TSB is factory repair guidance, not a recall — the repair is not automatically free.
See the 2020 Silverado 1500 TSB list →
Complaint history for this model year
When owners filed their reports — a long tail means problems kept surfacing for years.
Questions buyers ask
Is the 2020 Chevrolet Silverado 1500 reliable?
The 2020 Chevrolet Silverado 1500 drew 1,031 complaints in federal safety records — a middle-of-the-pack year for this model. Its trouble index is 32/100, scored against the model's worst year (1999).
What are the most common 2020 Chevrolet Silverado 1500 problems?
The top reported problems for the 2020 Chevrolet Silverado 1500 are engine (258 complaints), transmission & drivetrain (215), and electrical (114).
At what mileage do 2020 Chevrolet Silverado 1500 problems show up?
Owners most often report 2020 Chevrolet Silverado 1500 problems around 25,000 miles. Half of all reports that include an odometer reading fall between 4,000 and 78,000 miles.
Does the 2020 Chevrolet Silverado 1500 have recalls?
12 recall campaigns apply to the 2020 Chevrolet Silverado 1500. Recall repairs are free at any franchised dealer.
Every number on this page is a count of records in the federal complaint, recall, and investigation files published by NHTSA's Office of Defects Investigation. Check any specific vehicle's open recalls by VIN at nhtsa.gov/recalls.