2016 Honda Pilot TSBs
365 manufacturer communications for the 2016 Honda Pilot sit in NHTSA's public file. A TSB is factory repair guidance, not a recall — the repair is not automatically free. The 2016 Pilot problem report covers complaints, recalls, and investigations.
What the bulletins cover
Most recent service bulletins
The 20 most recent of 365 communications on file. The complete set is searchable on NHTSA's page for this vehicle.
Service Bulletin - Under certain circumstances, after coming to a stop and engaging idle stop, the vehicle may not restart automatically due to excessive cylinder pressure and/or low cranking torque. Typically, the customer can immediately restart the vehicle by selecting Park…
Service Bulletin - The AWD warning light is on potentially due to water intrusion into the rear differential pump motor connector area that corrodes the terminals.
Service Bulletin - Drivers may experience a chirping sound coming from the engine area with the engine warmed up due to the high pressure fuel pump is making a chirp.
Service Bulletin - MIL flashes and vehicle will not accelerate, low power. After cycling the ignition, the symptom does not return with no stored DTCs. This issue is more common in regions with cold weather (specifically near or below freezing temperatures). Usually after a long…
Service Bulletin - The A/C does not blow cold air, and the lower corner of the condenser around the receiver/dryer cap is stained due to a poor O-ring compression against the receiver/dryer barrel wall.
Service Bulletin - The MIL flashes and vehicle will not accelerate, low power. After cycling the ignition, the symptom does not return with no stored DTCs. This issue is more common in regions with cold weather (specifically near or below freezing temperatures). Usually after a…
Dealer Message - American Honda Motor Co., Inc. (AHM) is searching for certain 2019-2023 Passports, 2016-2022 Pilots, & 2017-2023 Ridgelines with a customer complaint of the front passenger’s power window inop from either the driver’s window switch, front passenger's window…
Dealer Message - American Honda Motor Co., Inc. (AHM) is searching for certain 2019-2023 Passports, 2016-2022 Pilots, & 2017-2023 Ridgelines with a customer complaint of the front passenger’s power window inop from either the driver’s window switch, front passenger's window…
Dealer Message - American Honda Motor Co., Inc. (AHM) is searching for certain 2019-2023 Passports, 2016-2022 Pilots, & 2017-2023 Ridgelines with a customer complaint of the front passenger’s power window inop from either the driver’s window switch, front passenger's window…
Dealer Message - American Honda Motor Co., Inc. (AHM) is searching for certain 2019-2023 Passports, 2016-2022 Pilots, & 2017-2023 Ridgelines with a customer complaint of the passenger’s power window inop from driver’s master window switch. Customer may also report that the…
Service Bulletin - Under certain circumstances, after coming to a stop and the idle stop feature engages, the vehicle may not automatically restart. Typically, the customer can immediately restart the vehicle by selecting Park and pushing the ENGINE START/STOP button.
Service Bulletin - The vehicle's transmission temperature can become too hot due to automatic transmission fluid deterioration causing high foaming and low viscosity. During extended high load driving, the automatic transmission fluid will foam and cooler flow rate is reduced.
Service Bulletin - The engine will not crank on initial startup after precipitation and sub-freezing temperatures. Water can enter the starter motor, and when temperatures drop below freezing, the water will freeze inside the starter motor. This will prevent the starter from…
Service Bulletin - There is a loud buzzing or whining when adjusting the driver’s or front passenger’s seat forward and backward. This is due to the issue that the flex cable in the seat adjustment mechanism is not correctly lubricated.
Warranty Extension - Warranty Extension reimbursement form for engine idle stop repairs made before the warranty extension notice date.
Warranty Extension - Under certain circumstances, after coming to a stop and the idle stop feature engages, the vehicle may not automatically restart.
Product Update - Honda is conducting a product update to your 2019-22 Passport, 2016-22 Pilot, and 2020-23 Ridgeline. Under certain circumstances, after coming to a stop and the idle stop feature engages, the vehicle may not automatically restart.
Service Bulletin - The headlight seal may become damaged from a misadjusted hood. Damage to the headlight seal may lead to moisture condensation building up in the headlight.
Service Bulletin - The engine will not crank on initial startup after precipitation and sub-freezing temperatures. Water can enter the starter motor, and when temperatures drop below freezing, the water will freeze inside the starter motor. This will prevent the starter from…
Service Bulletin - Under certain circumstances, after coming to a stop and the idle stop feature engages, the vehicle may not automatically restart. Typically, the customer can immediately restart the vehicle by selecting Park and pushing the ENGINE START/STOP button.
Every number on this page is a count of records in the federal complaint, recall, and investigation files published by NHTSA's Office of Defects Investigation. Check any specific vehicle's open recalls by VIN at nhtsa.gov/recalls.