2006 Ford Explorer TSBs

When performing any transmission fluid changes or topoffs involving MERCON SP, MERCON LV has replaced all versions of MERCON SP and can be used going forward. Mixing MERCON LV and MERCON SP in the same transmission is acceptable. After 30-Jun-2023, MERCON SP ATF will no longer…

Some 2000 and newer Ford, Lincoln and Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns appearing as bubbled and/or peeling paint with or without accompanying white dust. Panel replacement is recommended. Follow the Service Procedure steps to…

Some 2000 and newer Ford, Lincoln and Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns appearing as bubbled and/or peeling paint with or without accompanying white dust. Panel replacement is recommended. Follow the Service Procedure steps to…

This SKU is a front upper ball joint. The Customer communication requested return of unsold inventory to inspect for ball studs with excessive rotational friction in the ball joint assembly. Excessive friction in the ball joint assembly may cause a perceptible increase in…

Various vehicles equipped with a 4.6L, 5.4L, 6.8L modular 3 valve engine built on or before 8-Jan-2016 may exhibit symptoms that may include upper end engine noise, rough running, misfire and/or engine damage. If diagnosis leads to only camshaft/camshaft roller follower(s)…

The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. The IDS has a limited refresh rate when reading these PIDs and cannot…

FORD/MERCURY: TO PREVENT HARNESS DAMAGE, ON SOME VEHICLES, RESULTING IN CONTACT WITH TIRE OR SUSPENSION COMPONENTS, PROPER ROUTING OF WIRING HARNESS FOR WHEEL SPEED SENSOR IS KEY. 2006-2010 EXPLORER, MOUNTAINEER, EXPLORER SPORT TRAC.

FORD/LINCOLN/MERCURY: IF BATTERY WAS DISCONNECTED OR DEAD, VEHICLES/TRUCKS MAY EXPERIENCE HARD STARTS AND ENGINE IDLE RPM FLUCTUATION AND EXHIBIT DIAGNOSTIC TROUBLE CODES (DTCS) P0505, P0506, P2111 AND P2112.

FORD/MERCURY/LINCOLN: VEHICLES MAY EXHIBIT ONE OR MORE OF THE FOLLOWING SYMPTOMS: DRIVE AWAY HESITATION, LOSS OF RPM ON DECELERATION, DIFFICULTY STARTING, AND/OR IDLE RPM LESS THAN DESIRED. THE F53 MOTORHOME CHASSIS IS INCLUDED.

FORD: SOME VEHICLES MAY EXHIBIT OIL SEPARATION FROM THE INTERNAL LUBE FOUND IN THE UNITIZED CARTRIDGE SEAL. OIL SEPARATION APPEARS TO BE AND IS OFTEN MISDIAGNOSED, AS AN AXLE LUBE LEAK.

FORD/MERCURY: 4.0L/4.6L HARD START/ROUGH RUNNING; AFTER LONG HOT SOAK/DIP IN RPM WHEN COMING TO A STOP; BUILT ON OR BEFORE 4/2/08. MAY EXHIBIT A DIP IN RPM BELOW NORMAL IDLE LEVEL OF 600 RPM ON DECELERATION.

IMPROVED BRAKE PEDAL FEEL AND FIRMNESS.

FUEL FILL--SLOW OR EARLY SHUT OFF--BUILT BEFORE 11/28/2007.

SOME 1997-2008 VEHICLES EQUIPPED WITH A 4.6L 2V, 5.4L 2V, OR 6.8L 2V ENGINE--SPARK PLUG THREAD REPAIR PROCEDURE--NOT COVERED UNDER NEW VEHICLE LIMITED WARRANTY. *NJ THIS INCLUDES F-53 MOTORHOME CHASSIS. UPDATED 2/23/10.

FORD/MERCURY: SOME VEHICLES EQUIPPED WITH 6R60 TRANSMISSIONS MAY EXHIBIT VARIOUS TRANSMISSION PERFORMANCE ISSUES. WHEN COMPARED TO OTHER TRANSMISSIONS, SOME OF THE SHIFT CHARACTERISTICS ARE DIFFERENT THAN PREVIOUS MODELS DUE TO THE 100% SYNCHRONOUS DESIGN OF THE 6R60.

FRONT SEAT MANUAL LUMBAR INOPERATIVE.

THUMPING/LOUD FLUTTER - BEHIND DASH IN DEFROST MODE - LACK OF AIRFLOW TO FLOOR - MANUAL A/C.

LOWER STEERING COLUMN SHAFT POP/CLUNK NOISE.

MALFUNCTION INDICATOR LAMP (MIL) MAY NOT ILLUMINATE AND DIAGNOSITC TROUBLE CODES (DTC'S) MAY NOT BE SET WHEN A CERTAIN SENSOR OR NETWORK FAILURES OCCUR.

MIL ON WITH DTC P0463 OR ERRATIC FUEL GAUGE OPERATION.