2005 Ford Crown Victoria TSBs

This article supersedes TSB 19-2026 to update the vehicle model years affected. Some 2000 and newer Ford/Lincoln/Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns appearing as bubbled and/or peeling paint with or without accompanying white dust.…

Some 2000 and newer Ford, Lincoln and Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns appearing as bubbled and/or peeling paint with or without accompanying white dust. Panel replacement is recommended. Follow the Service Procedure steps to…

Some 2000 and newer Ford, Lincoln and Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns appearing as bubbled and/or peeling paint with or without accompanying white dust. Panel replacement is recommended. Follow the Service Procedure steps to…

The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. The IDS has a limited refresh rate when reading these PIDs and cannot…

For 2005-2012 Crown Victoria, 2005-2011 Grand Marquis and Town Car vehicles, Regional Program 13R01 applies to vehicles not registered in corrosion states and not included in Safety Recall 13S08, where operation in high corrosion areas for an extended period may lead to…

Inpected or repaired under 13R01 - Requests for recall service action under 13S08

SUMMARY TO BE PROVIDED ON A FUTURE DATE.

FORD: THE LOWER INTERMEDIATE STEERING SHAFT, HAS CORROSION OF SWING LINK JOINTS, COMBINED WITH COLLAPSED UPPER INTERMEDIATE STEERING SHAFT, RESULTING IN STEERING COLUMN SEPARATION AND LOSS OF STEERING CONTROL. MODEL 2005-2011 CROWN VICTORIA, GRAND MARQUIS, TOWN CAR. *PE UPDATED…

FORD: THE LIGHTING CONTROL MODULE HAS EXTENDED WARRANTY COVERAGE, ON CERTAIN VEHICLES, DUE TO A POSSIBLE CRACK ON SOLDER JOINT THAT CONNECTS RELAY TO CIRCUIT BOARD. MODEL 2003-2005 CROWN VICTORIA, GRAND MARQUIS.

FORD: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. INFORMATION REGARDING THE LIGHTING CONTROL MODULE EXTENDED WARRANTY COVERAGE, FOR SOME VEHICLES, TO 15 YEARS OR 250,000 MILES, WHICHEVER OCCURS FIRST. MODEL 2003-2005 VICTORIA, GRAND MARQUIS.

FORD: SWING LINK JOINTS ON LOWER INTERMEDIATE STEERING SHAFT, HAS CORROSION, AND COMBINED WITH COLLAPSED UPPER INTERMEDIATE STEERING SHAFT, ON SOME VEHICLES, CAUSES STEERING COLUMN TO SEPARATE, LEADING TO STEERING CONTROL LOSS. MODEL 2005-2011 CROWN VICTORIA, GRAND MARQUIS, TOWN…

FORD/LINCOLN/MERCURY: IF BATTERY WAS DISCONNECTED OR DEAD, VEHICLES/TRUCKS MAY EXPERIENCE HARD STARTS AND ENGINE IDLE RPM FLUCTUATION AND EXHIBIT DIAGNOSTIC TROUBLE CODES (DTCS) P0505, P0506, P2111 AND P2112.

FORD/MERCURY/LINCOLN: VEHICLES MAY EXHIBIT ONE OR MORE OF THE FOLLOWING SYMPTOMS: DRIVE AWAY HESITATION, LOSS OF RPM ON DECELERATION, DIFFICULTY STARTING, AND/OR IDLE RPM LESS THAN DESIRED. THE F53 MOTORHOME CHASSIS IS INCLUDED.

MALFUNCTION INDICATOR LAMP (MIL) ON--DIAGNOSTIC TROUBLE CODE (DTC) P2106 AND P061B--POLICE INTERCEPTOR BUILT BEFORE 10/19/2007.

SOME 1997-2008 VEHICLES EQUIPPED WITH A 4.6L 2V, 5.4L 2V, OR 6.8L 2V ENGINE--SPARK PLUG THREAD REPAIR PROCEDURE--NOT COVERED UNDER NEW VEHICLE LIMITED WARRANTY. *NJ THIS INCLUDES F-53 MOTORHOME CHASSIS. UPDATED 2/23/10.

REDUCTION IN POWER AT WIDE OPEN THROTTLE.

EXTENDED COVERAGE PROGRAM FOR FORWARD CLUTCH CYLINDER IN THE TRANSMISSION MAY CRACK AT THE SNAP RING GROOVE LOCATION CAUSING A LOSS OF CLUTCH CAPACITY AND THE EVENTUAL LOSS OF FORWARD GEARS. *TT SUPPLEMENT #2, OWNER NOTIFICATION. *TT SUPPLEMENT #4.

UN-COMMANDED TCC APPLY ON THE 1-2 SHIFT CAUSING PERCEPTION OF HESITATION AND/OR LACK OF POWER DURING SHIFT.

THE FORWARD CLUTCH CYLINDER IN THE TRANSMISSION MAY CRACK AT THE SNAP RING GROOVE LOCATION CAUSING LOSS OF CLUTCH CAPACITY AND THE EVENTUAL LOSS OF FORWARD GEARS. CUSTOMER SATISFACTION PROGRAM 06B36. *TT SUPPLEMENT #1. *TT SUPPLEMENT #2. *KB SUPPLEMENT #3.

CATALYTIC CONVERTER BRICK RATTLE OR BUZZING NOISE.